THERMAL SCIENCE

International Scientific Journal

Hongyu Zan

,

Rui Li

,

Ruiyi Li

,

Zhan Li

,

Jianming Yin

,

Zhe Huang

,

Pengbo Ma

,

Xiangte Chen

,

Shuanghui Deng

,

Xuebin WangORCID

LOW-TEMPERATURE PYROLYSIS UPGRADING OF LIGNITE: THREE-PHASE PRODUCT DISTRIBUTION AND CHARACTERIZATION

ABSTRACT
Lignite is one of the most abundant fossil energy resources worldwide. However, its high moisture and oxygen contents and low calorific value lead to low efficiency and severe pollutant emissions during direct combustion. Here, Indonesian lignite was upgraded via low-temperature pyrolysis under nitrogen in the range of 200-600°C, with systematic quantification and characterization of the gas, liquid and solid products. The results show that as the pyrolysis temperature increased, the solid yield gradually decreased, while the yields of liquid and gas products increased. In the gas products, the CO2 content decreased noticeably, while the content of combustible components, including CO, CH4, and H2, increased. Specifically, CH4 increased markedly beyond 400°C, and H2 rose significantly above 500°C. The liquid products were dominated by phenolic compounds, with low-molecular-weight phenols (such as phenol) as major constituents. A temperature of 400°C represents a key node where phenols become predominant and polycyclic aromatic hydrocarbons (PAHs) begin to emerge. Proximate/ultimate analyses and lower heating value (LHV) measurements of the chars demonstrated systematic fuel-property upgrading, with decreased volatile matter, increased fixed carbon, and an LHV increase from 18,723.4 to 30,714.74 kJ•kg-1. Thermogravimetric analysis (TGA) in air showed a single dominant derivative thermogravimetric (DTG) peak, and Coats-Redfern fitting over the main DTG peak interval indicated increasing apparent kinetic parameters with increasing pyrolysis severity. Overall, this study elucidates the temperature-dependent evolution of three-phase products during lignite low-temperature pyrolysis and provides data support for clean upgrading and graded utilization of lignite.
KEYWORDS
lignite, Pyrolysis upgrading, Low-temperature, Three-phase products, kinetic analysis
PAPER SUBMITTED: 2025-12-30
PAPER REVISED: 2026-04-21
PAPER ACCEPTED: 2026-04-17
PUBLISHED ONLINE: 2026-05-17
DOI REFERENCE: https://doi.org/10.2298/TSCI251330054Z
REFERENCES
[1] Chengyong, W., et al., Influential mechanism of pyrolysis pretreatment on wettability of Zhaotong lignite (in Chinese), Coal Conversion, 47 (2024), 1, pp. 10-18
[2] Qi, Z., Clean and efficient utilization of lignite resources in China (in Chinese), Clean Coal Technology, 24 (2018), 02, pp. 9-14
[3] Gao, Z., et al., Car-Parrinello molecular dynamics study on the interaction between lignite and water molecules, Fuel, 258 (2019), Dec.15, pp. 116189.1-116189.7, DOI No., 10.1016/j.fuel.2019.116189
[4] Guo, J., et al., Microscopic adsorption behaviors of ionic surfactants on lignite surface and its effect on the wettability of lignite: A simulation and experimental study, Journal of Molecular Liquids, 345 (2022), DOI No., 10.1016/j.molliq.2021.117851
[5] Yaying, Z., et al., The Experimental Study of Lignite Combustion Pollutant Emission Characteristics (in Chinese), Journal of Northeast Dianli University, 32 (2012), 02, pp. 33-37
[6] Ningzi, W., et al., Experimental study of coal pyrolysis in hydrogen atmosphere and coal char gasification characters (in Chinese), Coal Science and Technology, 45 (2017), 01, pp. 214-220, DOI No., 10.13199/j.cnki.cst.2017.01.034
[7] Jianxuan, S., et al., Coal grading utilization technologies based on coal pyrolysis:Review and prospect (in Chinese), Clean Coal Technology, 29 (2023), 07, pp. 1-20, DOI No., 10.13226/j.issn.1006-6772.F23053001
[8] Tahereh, H., et al., Energy Evaluation and Techno-economic Analysis of Low-Rank Coal (Victorian Brown Coal) Utilization for the Production of Multi-products in a Drying-Pyrolysis Process, Energy & Fuels, 32 (2018), 3, pp. 3211-3224
[9] Yan, J., et al., Comparative study of low-temperature pyrolysis and solvent treatment on upgrading and hydro-liquefaction of brown coal, Fuel, 199 (2017), pp. 598-605, DOI No., 10.1016/j.fuel.2017.03.029
[10] Chen, M., et al., Study on characterization of tri-phase products and microstructure evolution during in-situ pyrolysis of tar-rich coal at different temperatures, Fuel, 388 (2025), pp. 134562-134562
[11] Wo, J., et al., Morphological Characteristics of Chars Obtained from Low-Temperature Pyrolysis of Pulverized Lignite, Journal of Energy Engineering, 144 (2018), 3, DOI No., 10.1061/(ASCE)EY.1943-7897.0000525
[12] Wu, Y., et al., Effect of pyrolysis atmospheres on gaseous products evolution of coal pyrolysis at high temperature, Fuel, 366 (2024), DOI No., 10.1016/j.fuel.2024.131336
[13] Zhang, L., et al., Investigation on the Distribution of Yimin Lignite Pyrolysis Products and the Stability of its Char, ACS omega, 6 (2021), 22, pp. 13953-13961, DOI No., 10.1021/acsomega.0c05204
[14] Shi, Y., et al., Evolution mechanism of organic macromolecular structure during lignite pyrolysis, Journal of Analytical and Applied Pyrolysis, 181 (2024), DOI No., 10.1016/j.jaap.2024.106643
[15] Qi, J., et al., Heating-rate-dependent pyrolysis mechanism of Dayan lignite: Integrating experimental studies and ReaxFF-MD, Thermal Science and Engineering Progress, 66 (2025), p. 104027, DOI No., 10.1016/j.tsep.2025.104027
[16] Patel, V.R., et al., Kinetic Study of Indian Lignite by Model-Free Methods, Journal of The Institution of Engineers (India): Series C, 103 (2022), 4, pp. 837-845, DOI No., 10.1007/s40032-022-00859-z
[17] Korkmaz, A.A.,Y. Akbulut, Interpretation of combustion properties of raw-pyrolyzed lignite with kinetic data, International Journal of Coal Preparation and Utilization, 43 (2023), 7, pp. 1222-1233, DOI No., 10.1080/19392699.2022.2104266
[18] Sathiya, P.S., et al., Combustion and pyrolysis kinetics of Australian lignite coal and validation by artificial neural networks, Energy, 242 (2022), p. 122949, DOI No., 10.1016/j.energy.2021.122949
[19] Deng, S., et al., Thermogravimetric study on the Co-combustion characteristics of oily sludge with plant biomass, Thermochimica Acta, 633 (2016), pp. 69-76, DOI No., 10.1016/j.tca.2016.03.006
[20] Ahmad, M.B., et al., Investigation on co-combustion behavior of domestic waste and sewage sludge using TG-FTIR-Py-GC/MS: Thermal behavior and gaseous pollutants emission, Journal of the Energy Institute, 118 (2025), p. 101933, DOI No., 10.1016/j.joei.2024.101933
[21] Jin, Q., et al., Synergistic effects during co-pyrolysis of biomass and plastic: Gas, tar, soot, char products and thermogravimetric study, Journal of the Energy Institute, 92 (2019), 1, pp. 108-117, DOI No., 10.1016/j.joei.2017.11.001
[22] Deng, S., et al., Synergetic effects during co-pyrolysis of woody biomass and Zhundong coal, Thermal Science, 29 (2025), 2 Part A, pp. 931-941, DOI No., 10.2298/TSCI240324211D
[23] Zan, H.Y., et al., A comparative analysis of product distributions and characteristics from pyrolysis of broiler manure, naturally dried broiler manure, and layer hen manure, JOURNAL OF ANALYTICAL AND APPLIED PYROLYSIS , 194 (2026), DOI No., 10.1016/j.jaap.2025.107552
[24] Haq, S.R., et al., Thermogravimetric Analysis for Foundational Insights into the Drying Dynamics of Indonesian Low-Rank Coal, IOP Conference Series:Earth and Environmental Science, 1486 (2025), 1, DOI No., 10.1088/1755-1315/1486/1/012034
[25] Xiaoming, J., Analysis on safety and economy of Indonesia coal burned in boiler of a power plant (in Chinese), Boiler Manufacturing, (2018), 06, pp. 18-21
[26] Anthony, D.B.,J.B. Howard, COAL DEVOLATILIZATION AND HYDROGASIFICATION , AICHE JOURNAL, 22 (1976), 4, pp. 625-656, DOI No., 10.1002/aic.690220403
[27] Coats, A.W.,J.P. Redfern, KINETIC PARAMETERS FROM THERMOGRAVIMETRIC DATA, NATURE, 201 (1964), 491, pp. 68-&, DOI No., 10.1038/201068a0
[28] Xinggang, W., et al., Effects of reaction temperature and pressure on the distribution of lignite pyrolysis products in Santanghu Basin, Clean Coal Technology, 30 (2024), 6, pp. 114-127, DOI No., 10.13226/j.issn.1006-6772.XJ24050201
[29] Wu, F.-P., et al., Correlations of composition and structural characteristics between pyrolysis tar and soluble organic species of Baoqing lignite, Journal of Analytical and Applied Pyrolysis, 171 (2023), p. 105954, DOI No., 10.1016/j.jaap.2023.105954
[30] Gopinath, A., et al., Effects of the properties and the structural configurations of fatty acid methyl esters on the properties of biodiesel fuel: a review, PROCEEDINGS OF THE INSTITUTION OF MECHANICAL ENGINEERS PART D -JOURNAL OF AUTOMOBILE ENGINEERING, 229 (2015), 3, pp. 357-390, DOI No., 10.1177/0954407014541103
[31] Xu, Y., et al., Research status, industrial application demand and prospects of phenolic resin, RSC Advances, 9 (2019), 50, pp. 28924-28935, DOI No., 10.1039/C9RA06487G
[32] Ma, B., et al., Efficient separation of phenolic compounds from coal tar using environmentally friendly ionic liquids: extraction performance and mechanism analysis, Separation and Purification Technology, 382 (2026), p. 136140, DOI No., 10.1016/j.seppur.2025.136140
[33] Westerhof, R.J.M., et al., Fractional Condensation of Biomass Pyrolysis Vapors, Energy & Fuels, 25 (2011), 4, pp. 1817-1829, DOI No., 10.1021/ef2000322
[34] Lamichhane, S., et al., Polycyclic aromatic hydrocarbons (PAHs) removal by sorption: A review, Chemosphere, 148 (2016), pp. 336-353, DOI No., 10.1016/j.chemosphere.2016.01.036
[35] Fengchi, W., et al., Effects of Low-Temperature Pyrolysis Upgrading on Semi-Char of Lignite (in Chinese), Boiler Technology, 50 (2019), 3, pp. 7-12
[36] Songjiang, M., et al., Combustion performance of semi-coke from Inner Mongolia lignite under mild pyrolysis conditions, Journal of Coal Science & Engineering, 40 (2015), 05, pp. 1153-1159, DOI No., 10.13225/j.cnki.jccs.2014.1004
[37] Jinping, Z., et al., Physical/chemical structure evolution and combustion characteristics of mild thermally upgraded lignite (in Chinese), Journal of Coal Science & Engineering, 40 (2015), 03, pp. 671-677
PDF VERSION [DOWNLOAD]
Low-temperature pyrolysis upgrading of lignite: Three-phase product distribution and characterization

© 2026 Society of Thermal Engineers of Serbia. Published by the Vinča Institute of Nuclear Sciences, National Institute of the Republic of Serbia, Belgrade, Serbia. This article is an open access article distributed under the terms and conditions of the Creative Commons Attribution-NonCommercial-NoDerivs 4.0 International licence